Benzinrasenmäher | AL-KO Aldi Service

ALDI Service at a glance

Rasenmäher | AL-KO Service Aldi Garantie

Warranty

Our products meet the highest quality standards. Should a defect occur, you can download the warranty card for your device here.

Gardenline from 2019 >

Gardenline up to 2018 >

Extended warranty >

Instruction manual

Here you can download the appropriate operating instructions for your product. Do you have any further questions about functionality? Simply use the service form below.

Rasenmäher | AL-KO Service Aldi Bedienungsanleitungen
Rasenmäher | AL-KO Service Aldi Ersatzteile

Spare parts card

In our spare parts cards you will find the appropriate article numbers for all spare parts. You can then order these from authorised specialist dealers.

Gardenline from 2019 >

Gardenline up to 2018 >

Service workshops

Use the search function to find approved specialist dealers in your area for maintenance, repair and care of your AL-KO product.

Service Dealers >
Rasenmäher | AL-KO Service Aldi Servicewerkstätten

If you have any queries, please do not hesitate to contact us. We aim to respond within 48 hours.

FAQ
General

Which components are included in the scope of delivery?
What components are included in the scope of delivery of the GARDENLINE lawnmower:
1x petrol engine lawnmower
1x lower handlebar
1x upper handlebar
1x grass flap (1x flap, 1x spring, 1x rod, 2x plug)
1x grass catcher basket (1x level indicator, 1x fabric base, 1x handle cover, 1x metal bracket, 1x basket cover, 2x support plate)
1x operating instructions (lawnmower)
1x operating instructions (petrol engine)
1x screw set for grass catcher box and handle mounting
1x 5 l petrol canister (empty)
1x spare spark plug
1x spark plug spanner (1x socket spanner, 1x torsion bar)

What does EasyStart mean for the Briggs & Stratton engine?
The EasyStart technology makes it 30% easier to start and includes the following features: The starter engages earlier, providing a shorter and lighter pull on the starter rope. A new carburettor with improved flow guarantees easy starting at low revs. The improved ignition coil provides sufficient ignition energy even at low starter speed.

What does ReadyStart mean with the Briggs & Stratton engine?
The ReadyStart technology always supplies the carburettor with the right amount of petrol. The primer and choke do not need to be actuated. This prevents the engine from sinking due to too much petrol. This engine also has the same features as the EasyStart engine.

How do I store the lawn mower over the winter?
Clean the appliance, change the air filter, the spark plug and the oil. Sharpen and balance the blade. Store dry.

Can I also use my GL46 lawnmower for mulching?
You can also use the machine for mulching. To do this, you need a mulching wedge - this is available as an accessory with the article number 46374001 from your local dealer.

Before putting into operation

Which type of petrol can be used for this lawnmower (4-stroke engine)?
Any petrol with at least 77 oct. can be used ! SUPER fuel has 95 oct. and can therefore be used without hesitation. All our engines are E10-compatible - please note untreated fuel should be stored for a maximum of 4 weeks.

Which type of oil can be used for this lawnmower (4-stroke engine)?
Recommended is a SAE 30 engine oil, but a 5W30 or 10W40 can also be used.

Where can I find the right replacement blade for this lawnmower?
The suitable replacement blade for this lawnmower can be purchased from your local AL-KO dealer

The blade is not sharp. Can it be re-sharpened ?
No. The cutting edge is designed to ensure an optimum service life and should be replaced when blunt

During operation

What can I do if the motor does not start?
Press the primer button 3 times at intervals of 2 seconds each time. If the temperature is below 10°C, press the primer button 5 times at intervals of 2 seconds.

The lawn mower is difficult to start. Can I use starter spray?
We strongly advise against using starter spray. In the worst case, chemicals can lead to engine damage. We recommend the machine is checked and, if necessary, carburettor cleaning by a AL-KO service partner.

Why does the lawnmower run lumpy and/or cuts out immediately after starting it?
Check the tank contents - fill up with petrol if necessary. Some suction carburettors always leave a residue of one to two cm of fuel in the tank. Dirt can get into the carburettor due to residues in the fuel or a defective air filter. The carburettor must be removed and cleaned.

Why does the lawnmower's engine smoke white ?
The unit has been tilted incorrectly, oil is in the muffler and/or air filter. The air filter must be disassembled and cleaned. Then check and adjust the oil level in the engine. Then let the engine run, after a few minutes the smoke development decreases. Attention: unburnt engine oil drips out of the muffler leading to environmental pollution! To clean the unit, only tilt it according to the operating instructions. We recommend that you place the handlebar on the ground, the spark plug must be pointing upwards.

Why does the lawnmower's engine smoke black ?
The air filter may be dirty and must be replaced. The oil level in the engine must be checked and adjusted. Then let the engine run. If the smoke development does not decrease, we recommend that you contact your AL-KO service partner.

What should I do if the engine loses power or stops?
Possible reasons for this can be that the air filter is dirty/clogged, that the spark plug is sooty, that the petrol is dirty/old or that the silencer is damaged/clogged. Please carry out the appropriate cleaning and maintenance work or contact a AL-KO service partner.
If you cut very long grass, this requires a high engine power. As a rule of thumb, remember that you should not cut more than 1/3 of the length of the blade of grass. If this does not change the performance of your engine, we recommend that you contact your AL-KO service partner.

The motor "rings". What is the reason for the ?
Normally it is because there is no oil. Check your oil level with the dipstick and top up oil if necessary. If this does not solve the problem, please check that all external components such as the muffler, carburettor, spark plug and cable are correctly fitted and are also tight. If the problem still persists, we recommend that you contact your AL-KO service partner.

Do you have further questions or problems?
Use our free customer service for ALDI customers
Tel. +44 (0)1963 828055 (Mon – Fri 8:00am to 5:30pm)

Cookies

AL-KO Geräte GmbH and its partners need your consent (click on "I agree") for individual data uses in order to save and / or retrieve information on a device (IP address, user ID, browser information). The data is used for personalized ads and content, ad and content measurements and to gain knowledge about target groups and product developments. More information on consent and setting options is available here. By clicking on "Reject cookies" you can reject your consent at any time.

Use of Data

AL-KO Gardentech UK Ltd works with partners who also process the data retrieved from your device (tracking data) for their own purposes (e.g. creating profiles) / for the purposes of third parties. Against this background, not only the collection of tracking data, but also their further processing by these providers requires consent. The tracking data is only collected when you click on the "I agree" button specified in the banner. The partners are the following companies: Facebook Ireland Limited, Google Inc., Microsoft Ireland Operations Limited, Outbrain Inc., Colourmedia Ltd, The Rocket Science Group LLC.

Further information on data processing by these partners can be found in the Privacy Policy. The information is also available via a link at the bottom of the page.